Hybrid Heat Pump

Hybrid Heat pump by Original Twist

ultimate eco heating

Ultimate Eco-heating system

If you are looking at heat pumps then I’ll assume you will have seen this heating system which particularly favours daytime running of Air Source Heat Pumps (ASHP), a feature in keeping with the free power from PV panels.



showing the COP difference between ASHP and GSHP

Day COP vs. Night COP

I tend to favour the cheaper and simpler ASHP and this chart shows why. While the GSHP (black line) gradually loses performance over the winter the ASHP can always do better on warmer days (red line) making the two systems closely matched during the daytime, up until Christmas anyway. After that the daytime COP on the air source starts to improve while the ground source continues to deteriorate.  This is all reversed at night when the ground source is miles better than the air source blue line.

Even though the GSHP easily beats the night time ASHP (blue line) an ASHP system geared towards more daytime running would be a match for the much more expensive GSHP which, let’s face it, doesn’t always need to run at night at all.

However, some new electricity deals for electric car charging (5p/kW.hr at night) make a GSHP, with more night time running, quite compelling. It might not be quite so efficient but the running cost is only 25% that of daytime rates. The biggest attraction though is the Renewable Heat Incentive which is heavily biased towards GSHP at 20.89p/kW.hr versus half that for ASHP. In my view the Government have not thought it through properly; the rates compensate for the cost difference  between the systems and not for the performance gap if indeed there even is one.

If only there was a system that could cherry pick the best COP line on the chart for any particular moment but still keep the high RHI payment. It would need to extract heat from the air on most days – red line – and extract heat from the ground at night – black line. The air side would not run at night so the blue line can be ignored. The average COP over the season would be around 4 which improves on the ground source while still keeping the best incentive.

Such a system is easy really and not particularly expensive either.

 Original Twist Hybrid heat pump – it’s a GASHP.

overclock and tilt PV panels

PV overclock and tilt

This system is particularly suited to the off-grid brigade who need every trick to make a limited energy supply (like the 6kW overclock and tilt)  go further.



This is what makes up the system:-

GSHP unit

We start with a GSHP unit. I saw a 3kW one on EBAY for £1,500; maybe not MCS approved but that looks like a fair price for a unit that is actually simpler than a complete ASHP.  As the name implies we need to feed it with some warmed water from a ground loop or slinky and more on that later.

Air source module

There is already water going in and out of the GSHP unit so warming it with air is simple. Just connect a parallel circuit incorporating a couple of car radiators and a fan or two to make the equivalent of an ASHP for about £200. A simple solar controller brings in the AS module whenever it can contribute.

The air module can be a fairly simple DIY job:

Rads in back of a kitchen cupboard, fans in the door?    or

A trestle with rads either side and a fan in the base.    or

A stand with rads and 12v car fans – all waterproof.

Hybrid heat pump

Buffer tanks

Two buffer tanks are used to handle the cold water coming out of the GSHP and the warmed water going in. The tanks allow the air side to store daytime energy.

Warm air is a great resource so we decouple the air source module and let it run whenever there is a benefit, whether the heating demand is on or not. The cold tank will nearly always be available to charge and sometimes the hot tank too.  Like the solar stripper circuit on the heating system the solar controller switches tanks easily and simply. When the colder tank is warmed up the flow back into the slinkies is highly beneficial by raising the COP line slightly and delaying that end of season fall off in performance. The straight black line on the COP chart will bend upwards into better COP territory.

 Slinky coil

Normally the ground starts the winter at around 12C then the GSHP and cold weather gradually take that down to around 0C. Permafrost around slinkies is not unusual. Normal ground loops are designed to perform at the worst end of this so they have to be huge. Not so with ours which can be very much smaller because:-

The ground starts the winter overcharged. We dump heat into it in the summer.

Frequent recharging takes place.

The cold return is usually pre-warmed.

Day time running of the GSHP is less frequent so the ground temperature can recover better.

Towards the end of winter, as the air warms up, the Air Source Module takes on practically all the load. The end of season performance stress on the slinky design is avoided.

I’ve done a job where the slinky was trucked down from Switzerland along with a man in a white coat and a bill for thousands; a bit over the top when polyethylene tube from the local builders merchant would be just as good and cost under £300.

Air conditioning

The RHI rules forbid a combined chiller unit in the GSHP unit. No worries there mate. In the summer the cold tank can be left to get really cold and a coil can send the cold to the main heating system and onwards to the fan coil units.  Aircon sorted for almost no cost!

BTW – the heat pump  module will be making heat when the aircon is running so you can heat the pool! Think of the pool heat exchanger as just another radiator on the domestic circuit, it couldn’t be simpler or cheaper.


So that’s it. Better COPs than a GSHP or an ASHP, full RHI payments, aircon, ground loop recharge, smaller ground loops and much kinder to an off-grid PV system.  The smaller ground loop might just swing this for owners of regular sized gardens.

Thought for the day

The RHI pays for heat made but not the electricity used to make it. So on a COP of 4 they pay for an effective COP of 3.  So if we ran a 3kW GSHP for 4 hours at night on 5p/kW.hr (electric car rate) it would cost 60p. But we would be paid for 36kW.hrs produced at 20.89p      £7.52  NICE!

So, your PV panels run the heat pump for free during the day and you get paid for night time use – makes you think eh?

(Actually the RHI pays you based on your EPC total heat demand with the rate at 20.89p/kW.hr, and for 7 years too)